Preview

iPolytech Journal

Advanced search

Evaluation of a modernization project of the main condensate scheme at CHP-10 power unit No. 5 using its customized simulation model

https://doi.org/10.21285/1814-3520-2022-3-426-438

Abstract

We investigate the effect of modernizing the main condensate scheme applied at the power unit No.5, CHP-10 of Baikal Energy Company LLC, on its energy and economic efficiency using a customized simulation model. Simulation modelling was carried out in the Machine Program Building System software environment. The constructed model was verified using the results of measuring control parameters in several operating modes according to a three-stage procedure of verifying the mathematical models of complex thermal power units. We propose an original approach to modernizing the main condensate thermal scheme at the power unit under study in order to reduce the specific fuel consumption for balance-of-plant needs. The idea was to expand the main condensate scheme by including an additional sealing pump to the feedwater electric pumps of the 1Кs-20-110 unit in order to avoid the incorrect selection of condensate pumps. The study showed that the redistribution of the main condensate flow between the existing condensate pumps and the proposed 1Ks-20-110 sealing pump leads to a reduction in the specific fuel consumption for the electric energy generation to 0.32 g of fuel per kWh across the range of electrical loads from 137 to 150 mW. As a result, the net efficiency of the power unit can be raised by 0.03%. It should be noted that the proposed modernization project may reduce the consumption of electricity for balance-of-plant needs when the feedwater electric pump is switched to the standby mode during an emergency shutdown of the power unit. Based on the performed energy and economic calculations, energy savings for the period of 2019 comprise 82,653 kWh, while the total annual savings are estimated at 78,030 rubles. Thus, the conducted research demonstrates the high efficiency of applying simulation modelling in the study and optimization of existing thermal power plants.

About the Authors

F. V. Zabuga
Melentiev Energy Systems Institute SB RAS; Engineering Center “Irkutskenergo” LLC
Russian Federation

Fedor V. Zabuga, Postgraduate Student;; 2nd Category Industrial Engineer

130 Lermontov St., Irkutsk 664033, Russia

67 Ryabikova Blvd, Irkutsk 664043, Russia



V. E. Alekseyuk
Melentiev Energy Systems Institute SB RAS
Russian Federation

Vitaliy E. Alekseyuk, Cand. Sci. (Eng.), Junior Researcher, Department of Heat Power Systems

130 Lermontov St., Irkutsk 664033, Russia



References

1. Lazarev G. B. Efficiency management of thermal power plant auxiliaries. Nauchno-tekhnicheskij zhurnal «Energiya edinoj seti» = Energy of Unified Grid, Scientific and Technical Journal. 2012;5(5):58-67. (In Russ.).

2. Najimova A. M., Habibulina A. T. Energy resource-saving in a thermal power plant auxiliary // El-ektrotekhnicheskie sistemy i kompleksy = Electrotechnical Systems and Complexes. 2013;21:293-297. (In Russ.).

3. Sizov R. R. Reducing the specific consumption of electrical energy for own needs of the power unit auxiliaries of station No. 8 of the Zainskaya state district power station. Vestnik Kazanskogo gosudarstvennogo energeticheskogo universiteta = Bulletin of the Kazan State Power Engineer-ing University. 2015;3(27):129-131. (In Russ.).

4. Sobolev S. P. К-160-130 HТGZ steam turbine. Mos-cow: Energiya; 1980, 192 р. (In Russ.).

5. Zabuga F. V. Using K-160-130 steam turbine mathematical model for its process scheme modernization. In: Sistemnye issledovaniya v energetike: trudy molodyh uchenyh Institutа sistem energetiki imeni L.A. Melent'eva SO RAN = System research in power engineering: works of young scientists of Melentiev Energy Systems Institute SB RAS. Iss. 47. Irkutsk: Melentiev Energy Systems Institute of the Siberian Branch of the Russian Academy of sciences; 2017, p. 56–61. (In Russ.).

6. Zabuga F. V. Using power unit mathematical model for its technological scheme modernization. In: Sistemnye issledovaniya v energetike: trudy molodyh uchenyh Institutа sistem energetiki imeni L.A. Melent'eva SO RAN = System research in power engineering: works of young scientists of Melentiev Energy Systems Institute SB RAS. Iss. 48. Irkutsk: Melentiev Energy Systems Institute of the Siberian Branch of the Russian Academy of sciences; 2016, р. 51–56. (In Russ.).

7. Zabuga F. V., Alekseyuk V. E. Mathematical modelling of the CHP plant-10 power unit No 5 of “Baikal Energy Company” LLC to assess the efficiency of its modernisation. Vestnik Irkutskogo gosudarstvennogo tehnicheskogo universiteta = Proceedings of Irkutsk State Technical University. 2021;25(2):183-195. (In Russ.). https://doi.org/10.21285/1814-3520-2021-2-183-195.

8. Zabuga F., Alekseiuk V. Research based on mathematical modeling of CHP-10 power unit No. 5 “Baikal Energy Company” LLC to assess the efficiency of its modernization. In: Energy Systems Research 2021: Proceedings International Conference of Young Scientists. E3S Web Conference. 2021;289. https://doi.org/10.1051/e3sconf/202128902002.

9. Kler A. M., Dekanova N. P., Skripkin S. K., Mikheev A. V., Korneeva Z. R., Orekhov A. B. Mathematical modeling and optimization in operational problems of thermal power plants. Novosibirsk: Nauka; 1997, 120 p. (In Russ.).

10. Kler A. M., Tyurina E. A. Optimization studies of power plants and complexes. Novosibirsk: Geo; 2016, 298 p. (In Russ.).

11. Alexeyuk V. E. An improved technique for identifica-tion of mathematical models of thermal power equipment. Energy Systems Research. 2018;1(3):53-60. https://doi.org/10.25729/esr.2018.03.0007.

12. Alekseyuk V. E., Maksimov A. S., Safronov P. G. Improved identification methods for thermal power equipment mathematical models. iPolytech Journal. 2019;23(3):503-515. (In Russ.). https://doi.org/10.21285/1814-3520-2019-3-503-515.

13. Kler A. M., Alekseyuk V. E. Improving the accuracy of identifying mathematical model parameters of the existing thermal power equipment. Nauchnyi vestnik Novosibirskogo gosudarstvennogo tekhnicheskogo universiteta = Science bulletin of the Novosibirsk state technical university. 2019;3:57-76. (In Russ.). https://doi.org/10.17212/1814-1196-2019-3-57-76.

14. Kler А., Alekseiuk V., Maksimov А. An improved tech-nique for identification of mathematical model parameters of thermal power equipment and assessment of its performance. In: Energy Systems Research 2019: Proceedings International Conference of Young Scientists. E3S Web Conferences. 2019;114. https://doi.org/ https://doi.org/10.1051/e3sconf/201911406009.

15. Alekseiuk V. Improving the efficiency of the three-stage technique of mathematical model identification of complex thermal power equipment. In: ENERGY-21 – Sustainable Development & Smart Management: Proceedings E3S Web Conferences. 2020;209. https://doi.org/10.1051/e3sconf/202020903002.

16. Gamm A. Z. Statistical methods of electric power systems state estimation. Moscow: Nauka; 1976, 220 p. (In Russ.).

17. Huber P. J. Robust statistics. New York: John Wiley & Sons; 1981, 308 p.

18. Kler A. M. Effective methods of circuit-parametric optimization of complex thermal power plants: development and application. Novosibirsk: Geo; 2018, 145 р. (In Russ.).

19. Kler A. M., Zharkov P. V., Epishkin N. O. Parametric optimization of supercritical power plants using gradient methods. Energy. 2019;189:116230. https://doi.org/10.1016/j.energy.2019.116230.

20. Kler A. M., Potanina Y. M., Marinchenko A. Y. Cooptimization of thermal power plant flowchart, thermodynamic cycle parameters, and design parameters of com-ponents. Energy. 2020;193:116679. https://doi.org/10.1016/j.energy.2019.116679.


Review

For citations:


Zabuga F.V., Alekseyuk V.E. Evaluation of a modernization project of the main condensate scheme at CHP-10 power unit No. 5 using its customized simulation model. iPolytech Journal. 2022;26(3):426-438. (In Russ.) https://doi.org/10.21285/1814-3520-2022-3-426-438

Views: 778


Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 License.


ISSN 2782-4004 (Print)
ISSN 2782-6341 (Online)